In-vitro Biosorption of Lead and Zinc by using living Biomass of Aspergillus oryzae
By H. S. Ravikumar Patil, H. K. Makari and H. Gurumurthy
September 2007
The authors are Lecturers and Research Associates at the Department of Biotechnology of the GM Institute of Technology in Davangere, Karnataka, India
Abstract
Bioremediation for elimination of heavy metals gaining much importance through microorganisms .This study was aimed to in-vitro elimination of lead and zinc by using of filamentous fungi Aspergillus oryzae. Biosorption of Lead and Zinc by Aspergiilus oryzae was tested at 5 different initial concentrations ranging from 20 ppm to 100 ppm. The samples were analyzed for decrease in concentrations after 5 days incubation using Atomic Absorption Spectrophotometer (Chemito AA-203). Aspergillus oryzae showed the maximum percentage removal of Pb and Zn at 20 ppm concentration and minimum adsorption at 100 ppm. It was also observed that removal efficiency of Aspergillus oryzae decreases with increasing concentrations.
Key words: Biosorption, Lead, Zinc, Fungi, Heavy Metals
Introduction
Heavy metals are among the most toxic contaminants present in the environment. Contamination of the aqueous environment by heavy metals is a worldwide environmental problem and as a result, their removal from waste water has attracted much attention from researchers in the past 20 years. Pollutant metals including Cu, Zn, Cd, Pb, Fe, Ni, Ag, Th, Ra and U released into the environment persist indefinitely, circulating and eventually accumulating throughout the food chain becoming serious threat to the environment and pose health problems.
Heavy metals traditionally removed by physical- chemical processes; Ion exchange, reverse osmosis, precipitation, solvent extraction, membrane technologies, electrochemical treatments. These techniques have significant disadvantages including incomplete metal removal, the need of expensive monitoring equipments and some physical methods not suitable to remove heavy metal concentration in the order of 1-100mg (Volesky and Holon, 1995). The use of microorganisms to remove metals is an emerging technology and gaining attention among environmental research communities. Microorganisms do not degrade metals but may immobilize metal precipitation from polluted environment. Recent works have revealed the potential of using microorganisms for the reduction of metals. The interaction of microorganisms and many pollutant metals has not been fully understood.
Zinc is one of the most common elements in the Earth crust. Zinc is found in the air, soil and water and is present in all foods. Atomic Weight of zinc is 65.38. Zinc has a melting point of 419.58°C, boiling point of 907°C, with a valence of 2. In its pure elemental (or metallic) form, zinc is a bluish-white. Recommended Dietary Allowances for zinc is 11 mg/day for men and 8 mg/day for women. If large doses of zinc are taken by mouth even for a short time stomach cramps, nausea, and vomiting may occur. Ingesting high levels of zinc for several months may cause anemia, damage the pancreas, and decrease the levels of high-density lipoprotein (HDL) cholesterol. . Zinc may be taken up by animals from soil or drinking water.
Lead occurs naturally in the environment and it is one out of four metals that have the most damaging effects on human health. Atomic number of lead is 82. Its melting point and boiling point are 327 °C and 1755 °C respectively. Lead is a bluish-white lustrous metal. Lead fulfils no essential function in the human body. It can enter the human body through uptake of food, water and air. It can cause several unwanted effects, such as rise in blood pressure, kidney damage, disruption of nervous systems, brain damage and declined fertility of men through sperm damage.
Some biomasses of fungi types are very effective in accumulating heavy metals, such as Aspergillus niger, Aspergillus terreus, Rhizopus oryzae, Penicillium chrysogenum, Metarrhizium anisopliae var. anisopliae and Penicillium verrucosum. Yeast such as Saccharomyces cerevisiae and Rhodotorula mucilaginosa, Algae such as Chlorella vulgaris and bacteria such as Bacillus subtilis and Pseudomonas aeruginosa (Goomes et al., 1998). Fungi group has shown better accumulation of nickel and chromium by physico-chemical and biological mechanisms including extra cellular binding by metabolism-dependent accumulation (Volesky and Holan, 1995).
Filamentous fungi may be better suited for this purpose than other microbial groups, because of their high tolerance towards metals, cell wall binding capacity and intracellular metal uptake capabilities. With all these considerations our present research intended find out more information on biosorption models with reference to best combination of metals, biomass types and assessment of biosorption efficiency.
Materials and Methods
Stock solutions of lead and Zinc were prepared in different initial concentrations ranging from 20ppm, 40ppm, 60ppm, 80ppm and 100ppm and added to sterilized each 50 ml of SD broth in separate conical flasks. Then inoculated with two loopful of A.oryzae spores. Experimental set up was incubated for five days at room temperature. Observation was made for colour changes in fungal mat.
The fungal mat was removed by filtration method by using A1 filter paper and collected the filtrate from each conical flask.The filtrate samples were subjected to atomic absorption analysis to determine the residual concentration of metal in the medium was analysed by Atomic Absorption Spectrophotometer( Chemito A A 203)
Results and Discussion
Studies on biosorption of Lead and Zinc from stock solutions by A.oryzae was incubated for a period of 5 days at five different initial concentrations of 20, 40, 60, 80, and 100ppm
Table 1 · The absorption capacity of A. oryzae for different concentration of Lead (Pb) at 5 day incubation
| Initial conc. of Pb in medium (ppm) |
Residual conc. of Pb in Medium (ppm) |
Amount of Pb absorbed by fungal mat (ppm) |
% of Pb absorbed by fungal mat (ppm) |
| Test 1 |
Test 2 |
Avg |
| 20 |
1.855 |
1.802 |
1.828 |
18.172 |
90 |
| 40 |
7.699 |
7.100 |
7.399 |
32.601 |
81 |
| 60 |
28.756 |
31.106 |
29.931 |
30.069 |
50 |
| 80 |
50.703 |
58.297 |
54.5 |
25.5 |
26 |
| 100 |
73.936 |
80.558 |
77.247 |
22.753 |
22 |
Table 2 · The absorption capacity of A. oryzae for different concentration of Zinc (Zn) at 5 day incubation
| Initial conc. of Zn in medium (ppm) |
Residual conc. of Zn in Medium (ppm) |
Amount of Zn absorbed by fungal mat (ppm) |
% of Zn absorbed by fungal mat (ppm) |
| Test 1 |
Test 2 |
Avg |
| 20 |
0.889 |
0.823 |
0.856 |
19.114 |
95 |
| 40 |
2.244 |
2.35 |
2.297 |
37.703 |
94 |
| 60 |
8.56 |
10.55 |
9.555 |
50.445 |
84 |
| 80 |
13.24 |
19.402 |
16.326 |
63.674 |
79 |
| 100 |
45.271 |
54.225 |
49.748 |
50.252 |
50 |
Colour Morphology
Table 3 · The color morphology of A.oryzae for different concentration of Lead at 5 day incubation
| Initial conc. of Pb in medium (ppm) |
Color of the mycelial biomass of A.oryzae |
| Control |
Green |
| 20 |
Parrot green |
| 40 |
Parrot green |
| 60 |
Creamish white |
| 80 |
Creamish white |
| 100 |
White |
Table 4 · The color morphology of A.oryzae for different concentration of Zinc at 5 day incubation
| Initial conc. of Zn in medium (ppm) |
Color of the mycelial biomass of A.oryzae |
| Control |
Green |
| 20 |
Green |
| 40 |
Green |
| 60 |
Green |
| 80 |
Slight greenish |
| 100 |
Pale green |
Conclusion
This study leads to the conclusion that A. oryzae have the capacity to accumulate Lead and Zinc. It showed higher sorption for Zinc than Lead. This high Zinc absorption capacity made them well suited for removal of heavy metal from contaminated water, bioleaching, bioremediation of polluted sites and effluent treatment.
Biosorption is highly economical and ecofriendly as this generate no further waste into the environment. However there are still many uncertainities associated with the development of treating waste water by living fungi and more future work is necessary.
Usage of fungi may become boon to maintain ecological balance in nature.
References:
- Ahmet., Semra. and Figen., 2005. Pb2+ Biosorption by Pretreated Fungal Biomass. Turk Journal of Biology. 26, p. 23-28.
- Asku, Z., Kutsal, T. Gun., S. Haciosmanoglu., N. and Gholminejad., 1991. Investigation of biosorption of Cu(II), Ni(II), and Cr(VI) ions to activated sludge bacteria. Environmental Technology, 12, p. 915-921.
- Aksu, Z., 1992. The biosorption of copper (II) by C. vulgaris and Z. ramigera. Environmental Technoology., 13: 579-586.
- Brady, D. and Ducan, J.R., 1994. Bioaccumulation of cations by Saccharomyces cerevisia., Applied Microbial Biotechnology, 34, p. 149-154.
- Bina, B. Kermani, M. Mohavahedian, H. and Khazaei, Z., 2006. Biosorption and Recovery of Copper and Zink from Aqueous solutions by non living biomasses of marine algae of Sargassum sp. Pakistan Journal of Biological Sciences. 9 (8): 1525-1530.
- Brierley, C.L., 1989. Bioremediation of metal contaminated surface and Groundwater. Geomicrobiology Journal, 8:201-223 25. G.M. Gadd, Fungi and Yeasts for metal accumulation. In: c.L Ehrlich, Brierly, (Eds), Microbial Mineral Recovery. McGrawHill, New York, 249-276.
- Bruno, C., Pablo, L., Robert, H. and Manuel, E.S., 2004. Biosorption of cadmium by Ficus spiralis. Environmental chemistry. 1. p. 180-187.
- Brown, M.J. and Lester, J.N., 1982. Role of bacterial extra cellular polymers in metal uptake in pure bacterial culture and activated sludge. Water Research, 16, p. 1539-1548.
- Butter, T. J., Evison, L. M., Hancooh., Matis, K. A. and Zouboulis, A., 1998. The removal of cadmium for dilute aqueous solution by biosorption and electrolysis at laboratory scale. Water Resource. 32(2), p. 400-406.
- Dias, M A., Lacerda, I.C.A., Pimentel Castro, P.F. and Rosa, C.A., 2002. Removal of heavy metals by an Aspergillus terreus strain immobilized in a polyurethane matrix. Letters in Applied Microbiology, 34, p. 46-50.
- Fourest, E. and Roux, C.J., 1992. Heavy metal biosorption by fungal mycilial by- products: mechanisms and influence of pH. Applied Microbiology and Biotechnology, 37, no. 3, p. 399-403.
- Gadd, G. M. and White, C., 1999. Microbial treatment of metal pollution – a working biotechnology?, Trends in Biotechnology, 11,353-359.
- Goomes, N.C.M., Mendonca-Hagler, L.C.S. and Savvadis I., 1998. Metal bioremediation by microorganisms. Brazilian Journal of Microbiology, 29, 85-92.
- Hussein, H., Ibrahim, S. F. and Kandeel, K., 2005. Biosorption of heavy metals from waste water using Pseudomonas sp., Electronic Journal of Biotechnology, 56, 197-103.
- Hammaini, A., 2003. Simultaneous uptake of metals by activated sludge. Minerals Engineering. 16, p. 723-729.
- Iqbal, A., Zafar, S. and Ahmad, F., 2005. Heavy metal biosorption potential of Aspergillus and Rhizopus sp. Isolated from wastewater treated soil. Journal of Applied Scinces and Environmental Management. 9. (1). P. 123-126.
- Jalali, R., Ghafourian, H., Asef, Y., Davarpanah, S.J. and Sepehr, S., 2002. Removal and recovery of lead using nonliving biomass of marine algae. Journal of Hazardous Materials, 92, no. 3, p. 253-262.
- Kapoor, A. and Viraraghavan, T., 1995. Fungal Biosorption: An alternative treatment option for heavy metal bearing wastewater: A review. Bioresource Technology, vol.53, 195-206.
- Karthikeyan, S. and Balasubramanian R., 2007. Evaluation of the marine algae Ulva fasciata and Sargassum sp. for the biosorption of Cu(II) from aqueous solutions. Bioresource Technology, vol. 98, p. 452-455
- Muhamad, N., Parr, J., Smith, D.M. and Wheatley, D.A., 1998. Adsorption of heavy metals in slow sand filters. In: Proceedings of the WEDC Conference Sanitation and water for all, p. 346-349.
- Norton, L., 2003. Biosorption of zinc from aqueous solutions using biosolids. Advances in Environmental Research, 56, p. 156-162.
- Pagnanelli, F., Toro, L. and Veglio, F., 2002. Olive mill solid residues as heavy metal sorbent material: a preliminary study. Waste Management, 22, 901-907.
- Shumate, E.S. and Strandberg, W.G. 1985. Accumulation of metals by microbial cells. Comprehensive Biotechnology, 13, p. 235-247.
- Tsezos, M. and Deutschmann, A.A. 1992. The use of mathematical model for the study of important parameters in immobilized biomass biosorption. Journal of Chemical Technology and Biotechnology, 53, p. 1-12.
- Tsezos M. 1982. The mechanism of uranium biosorption by Rhizopus arrhizus. Biotechnol. Bioeng, 24, 385-401.
- Tsezos, M. and Volesky, B. 1981. Biosorption of uranium and thorium. Biotechnology and Bioengineering, 24, p. 385-401.
- Vijay Raghavan, K., Jegan, J.R., Palanivelu and Velan. 2004. Copper removal from aqueous solution by marine green alga Ulva reticula. Electronic Journal of Biotechnology, 22, p. 61-71.
- Volesky, B.and Holan., 1995. Biosorbent Materials, Biotechnlogy and Bioengineering Symposium, 16, p. 121-126
- Volesky, B. 1990. Removal and recovery of heavy metals by biosorption. In: Biosorption of heavy metals. Boston, USA, CRC press, b, p. 7-43.
- Yekta, G., Uren, S. and Guvenc, U. 2003. Biosorption of Copper Ions by Caustic treated Waste Baker’s Yeast Biomass. Turk Journal of Biology. 27. p.23-29.
- Yang, J. and Volesky, B., 1999. Biosorption of uranium on Sargassum biomass. Water Research, 33(15) p.3357-3363.
- Yi-Tin, Wang., Evans, M., Chirwa. and Shen, H. 2000. Cr (VI) reduction in continuous-flow coculture bioreactor. Journal of Environmental Engineering, 21, p. 300-312.
***
Copyright © 2007, ECO Services International